A wheelbarrow is a small hand-propelled vehicle, usually with just one wheel, designed to be pushed and guided by a single person using two handles at the rear, or by a sail to push the ancient wheelbarrow by wind. The term "wheelbarrow" is made of two words: "wheel" and "barrow." "Barrow" is a derivation of the Old English "bearwe" which was a device used for carrying loads.
The wheelbarrow is designed to distribute the weight of its load between the wheel and the operator, so enabling the convenient carriage of heavier and bulkier loads than would be possible were the weight carried entirely by the operator. As such it is a second-class lever. Traditional Chinese wheelbarrows, however, had a central wheel supporting the whole load. Use of wheelbarrows is common in the construction industry and in gardening. Typical capacity is approximately 100 litres (3.53 cubic feet) of material.
A two-wheel type is more stable on level ground, while the almost universal one-wheel type has better maneuverability in small spaces, on planks, in water, or when tilted ground would throw the load off balance. The use of one wheel also permits greater control of the deposition of the load upon emptying.
Eastern Han tomb brick showing a wheelbarrow
The earliest wheelbarrows with archaeological evidence in the form of a one-wheel cart come from second century Han Dynasty Emperor Hui's tomb murals and brick tomb reliefs. The painted tomb mural of a man pushing a wheelbarrow was found in a tomb at Chengdu, Sichuan province, dated precisely to 118 AD. The stone carved relief of a man pushing a wheelbarrow was found in the tomb of Shen Fujun in Sichuan province, dated circa 150 AD. And then there is the story of the pious Dong Yuan pushing his father around in a single-wheel lu che barrow, depicted in a mural of the Wu Liang tomb-shrine of Shandong (dated to 147 AD). Earlier accounts dating to the 1st century BC and 1st century AD that mention a "deer cart" (luche) might also have been referencing a wheelbarrow.
The 5th-century Book of Later Han stated that the wife of the once poor and youthful imperial censor Bao Xuan helped him push a lu che back to his village during their feeble wedding ceremony, around 30 BC. Later, during the Red Eyebrows Rebellion (c. 20 AD) against Xin dynasty's Wang Mang (45 BC–23 AD), the official Zhao Xi saved his wife from danger by disguising himself and pushing her along in his lu che barrow, past a group of brigand rebels who questioned him, and allowed him to pass after he convinced them that his wife was terribly ill. The first recorded description of a wheelbarrow appears in Liu Xiang's work Lives of Famous Immortals. Liu describes the invention of the wheelbarrow by the legendary Chinese mythological figure Ko Yu, who builds a "Wooden ox".
Nevertheless, the Chinese historical text of the Sanguozhi (Records of the Three Kingdoms), compiled by the ancient historian Chen Shou (233–297 AD), credits the invention of the wheelbarrow to Prime Minister Zhuge Liang (181–234 AD) of Shu Han from 197–234. It was written that in 231 AD, Zhuge Liang developed the vehicle of the wooden ox and used it as a transport for military supplies in a campaign against Cao Wei.
Centrally mounted wheel
Further annotations of the text by Pei Songzhi (430 AD) described the design in detail as a large single central wheel and axle around which a wooden frame was constructed in representation of an ox. Writing later in the 11th century, the Song Dynasty (960–1279) scholar Gao Cheng wrote that the small wheelbarrow of his day, with shafts pointing forward (so that it was pulled), was the direct descendant of Zhuge Liang's wooden ox. Furthermore, he pointed out that the third century 'gliding horse' wheelbarrow featured the simple difference of the shaft pointing backwards (so that it was pushed instead).
Wheelbarrows in China came in two types. The more common type after the third century has a large, centrally mounted wheel. Prior types were universally front-wheeled wheelbarrows. The central-wheeled wheelbarrow could generally transport six human passengers at once, and instead of a laborious amount of energy exacted upon the animal or human driver pulling the wheelbarrow, the weight of the burden was distributed equally between the wheel and the puller. European visitors to China from the 17th century onwards had an appreciation for this, and it was given a considerable amount of attention by a member of the Dutch East India Company, Andreas Everardus van Braam Houckgeest, in his writings of 1797 (who accurately described its design and ability to hold large amounts of heavy baggage). However, the lower carrying surface made the European wheelbarrow clearly more useful for short-haul work. As of the 1960s, traditional wheelbarrows in China were still in wide use.
Chinese sailing carriage
Wheelbarrows near Xi'an
, c.1905 by Baptist missionary John Shields
Although there are records of Chinese sailing carriages from the 6th century these land sailing vehicles were not wheelbarrows, and the date of which the sail assisted wheelbarrow was invented is uncertain. Engravings are found in van Braam Houckgeest's 1797 book.
European interest in the Chinese sailing carriage is also seen in the writings of Andreas Everardus van Braam Houckgeest in 1797, who wrote:
Near the southern border of Shandong one finds a kind of wheelbarrow much larger than that which I have been describing, and drawn by a horse or a mule. But judge by my surprise when today I saw a whole fleet of wheelbarrows of the same size. I say, with deliberation, a fleet, for each of them had a sail, mounted on a small mast exactly fixed in a socket arranged at the forward end of the barrow. The sail, made of matting, or more often of cloth, is five or six feet (152 or 183 cm) high, and three or four feet (91 or 122 cm) broad, with stays, sheets, and halyards, just as on a Chinese ship. The sheets join the shafts of the wheelbarrow and can thus be manipulated by the man in charge.
These sailing wheelbarrows continued in use into the twentieth century.
Ancient Greece and Rome
The wheelbarrow may have existed in ancient Greece. Two building material inventories for 408/407 and 407/406 BC from the temple of Eleusis list, among other machines and tools, "1 body for a one-wheeler (hyperteria monokyklou)" (ὑπερτηρία μονοκύκλου in Greek):
Since dikyklos (δίκυκλος) and tetrakyklos (τετράκυκλος) mean nothing but "two-wheeler" and "four-wheeler," and since the monokyklos (μονόκυκλος) body is sandwiched in the Eleusis inventory between a four-wheeler body and its four wheels, to take it as anything but a one-wheeler strains credulity far beyond breaking point. It can only be a wheelbarrow, necessarily guided and balanced by a man...what does now emerge as certainty is that the wheelbarrow did not, as is universally claimed, make its European debut in the Middle Ages. It was there some sixteen centuries before.
Although evidence for the wheelbarrow in ancient farming and mining is absent and there is "no more evidence for Greek farmers, porters, miners, or soldiers employing the wheelbarrow than there is for their Roman counterparts," the English researcher in industrial archaeology M.J.T. Lewis surmises that wheelbarrows were not uncommon on Greek construction sites for carrying moderately light loads and may have been adopted by the Romans. It is unknown what the Greek wheelbarrow looked like. No wheelbarrow remains of significant age have been found and illustrations of wheelbarrows do not become common until the late Medieval era. The 4th century Historia Augusta reports emperor Elagabalus to have used a wheelbarrow (Latin: pabillus from pabo, one-wheeled vehicle) to transport women in his frivolous games at court. While the present evidence does not indicate any use of wheelbarrows into medieval times, the question of continuity in the Byzantine Empire is still open due to a lack of research. The wheelbarrow might have been transmitted to China before disappearing in Western Europe.
Types of medieval wheelbarrows
The first wheelbarrows in medieval Europe appeared sometime between 1170 and 1250. These types universally featured a wheel at or near the front (in contrast to their Chinese counterparts, which typically had a wheel in the center of the barrow), the arrangement now universally found on wheelbarrows.
Research on the early history of the wheelbarrow is made difficult by the marked absence of a common terminology. The historian of technology M.J.T. Lewis has identified in English and French sources four mentions of wheelbarrows between 1172 and 1222, three of them designated with a different term. According to the medieval art historian Andrea Matthies, the first archival reference to a wheelbarrow in medieval Europe is dated 1222, specifying the purchase of several wheelbarrows for the English king's works at Dover. The first depiction appears in an English manuscript, Matthew Paris's Vitae duorum Offarum, completed in 1250.
By the 13th century, the wheelbarrow proved useful in building construction, mining operations, and agriculture. However, going by surviving documents and illustrations the wheelbarrow remained a relative rarity until the 15th century. It also seemed to be limited to England, France, and the Low Countries.
The oldest wheelbarrows preserved from Central Europe were found in 2014 and 2017 during archaeological excavations in Ingolstadt, Germany. The felling dates of the trees that make up the wheelbarrow boards could be dendrochronologically dated to 1537 for one wheelbarrow and the 1530s for the other.
In the 1970s, British inventor James Dyson introduced the Ballbarrow, an injection molded plastic wheelbarrow with a spherical ball on the front end instead of a wheel. Compared to a conventional design, the larger surface area of the ball made the wheelbarrow easier to use in soft soil, and more laterally stable with heavy loads on uneven ground.
The Honda HPE60, an electric power-assisted wheelbarrow, was produced in 1998.
Power assisted wheelbarrows are now widely available from a number of different manufacturers. Powered wheelbarrows are used in a range of applications; the technology has improved to enable them to take much heavier loads, beyond weights that a human could transport alone without assistance. Motorized wheelbarrows are generally either diesel powered or electric battery powered. Often used in small-scale construction applications where access for larger plant machinery might be restricted.
- ^ Needham, Volume 4, Part 2, 263-267.
- ^ a b c Needham, Volume 4, Part 2, 265.
- ^ Needham, Volume 4, Part 2, 264-265.
- ^ Needham, Volume 4, Part 2, 263.
- ^ Needham, Volume 4, Part 2, 265.
- ^ Rezende, Lisa (2007). Chronology of Science. Checkmark Books (published April 1, 2007). pp. 40. ISBN 978-0816071197.
- ^ Needham, Volume 4, Part 2, 259-260.
- ^ a b Needham, Volume 4, Part 2, 260.
- ^ a b Needham, Volume 4, Part 2, 262.
- ^ M. J. T. Lewis, p.473
- ^ Needham, Volume 4, Part 2, 258-259.
- ^ Needham, Volume 4, Part 2, 259.
- ^ Andrea L. Matthies, p.363
- ^ Joseph Needham, Science and Civilisation in China, vol. 4, Physics and Physical Technology, pt. 2, Mechanical Engineering (Cambridge, 1965), p. 272
Needham 1965, pp. 274–6 harvnb error: no target: CITEREFNeedham1965 (help)
- ^ Temple (1986) Page 195.
A.E. van Braam Houckgeest (1797). An Authentic account of the Embassy of the Dutch East India Company to...China. quoted in Temple 1985, p196
- ^ Needham, Volume 4, Part 2, 274.
- ^ M. J. T. Lewis, p.470ff.
- ^ M. J. T. Lewis, p.472&475
- ^ M. J. T. Lewis, p.456, 468"
- ^ a b M. J. T. Lewis, p.473
- ^ M. J. T. Lewis, p.472
- ^ M. J. T. Lewis, p.456
- ^ Charlton T. Lewis, Charles Short, A Latin Dictionary, 1879: Pabo
- ^ Charlton T. Lewis, Charles Short, A Latin Dictionary, 1879: Pabillus
- ^ Historia Augusta: The Life of Elagabalus, Part 2, 29
- ^ M. J. T. Lewis, p.474
- ^ M. J. T. Lewis, pp.453-55
- ^ M. J. T. Lewis, p.463
- ^ Andrea L. Matthies, p.357
- ^ Andrea L. Matthies, p.358
The often held view that a wheelbarrow shows up in a stained-glass window at Chartres soon after 1200 is according to Lewis "a myth. There is none. The nearest approach is a handbarrow." (M.J.T. Lewis, p.463)
- ^ M. J. T. Lewis, p.456
- ^ Andrea L. Matthies, p.358
- ^ Schönauer, Tobias; Hohrath, Daniel (2019), "Wheelbarrow", Forms Of War 1600-1815 (PDF), Cataogues of Bayerisches Armeemuseum, 19, Ingolstadt: Ph.C.W. Schmid, p. 193, ISBN 978-3-96049-079-1, retrieved 2020-11-26
- ^ "Die erste Schubkarre der alten Schanzer - Ein außergewöhnlicher Fund vom Gießereigelände" [The first wheelbarrow of the old Schanzer - an unusual find from the cannon foundry site]. Actual News (in German). City of Ingolstadt. Retrieved 2019-04-15.
- ^ "Honda Worldwide | News Release | April 27, 1998". World.honda.com. 1998-04-27. Retrieved 2014-08-25.
- ^ "HPE60 video demonstration". World.honda.com. Archived from the original on 2012-12-28. Retrieved 2014-08-25.
- ^ "Electric Wheelbarrow". nu-starmhl.com.
- M. J. T. Lewis, "The Origins of the Wheelbarrow," Technology and Culture, Vol. 35, No. 3. (Jul., 1994), pp. 453–475
- Andrea L. Matthies, "The Medieval Wheelbarrow," Technology and Culture, Vol. 32, No. 2, Part 1. (Apr., 1991), pp. 356–364
- Needham, Joseph (1965). Science and Civilisation in China: Volume 4, Physics and Physical Technology, Part 2, Mechanical Engineering; rpr. Taipei: Caves Books Ltd.